- whatsapp +51955515985
- support@ecuforcetruck.com
- 24/7 Customer Support
Menu
Shop
Account
Subtotal: $0.00
No products in the cart.
Cummins ISB6.7 CM2350 (2013-17) Fault Code: 5278 PID: SPN: 6802 FMI: 31 Aftertreatment 1 Diesel Exhaust Fluid Dosing System Frozen – Condition Exists. The ECM has detected conditions which indicate the Diesel Exhaust Fluid Dosing System is frozen.
Circuit Description
The aftertreatment diesel exhaust fluid tank heater keeps the diesel exhaust fluid from freezing in the diesel exhaust fluid tank. The tank heater consists of an electrically powered tank heater control valve which controls the flow of engine coolant to a heating coil inside the diesel exhaust fluid tank. The tank heater control valve opens to allow coolant to flow to the heating coil when heating is commanded, and closes when heating is no longer required.
Component Location
The diesel exhaust fluid tank heater control valve is located near the diesel exhaust fluid tank. Specific location will vary depending on the OEM. The tank heating coil is internal to the diesel exhaust fluid tank.
Conditions for Running the Diagnostics
This diagnostic runs continuously when the engine is running.
Conditions for Setting the Fault Codes
The Engine Control Module (ECM) detected the diesel exhaust fluid dosing system was unable to prime when the ambient air temperature was low (non-heated diesel exhaust fluid dosing systems).
Action Taken When the Fault Code is Active
1)The ECM illuminates the amber CHECK ENGINE lamp and/or the Malfunction Indicator Lamp (MIL) immediately when the diagnostic runs and fails.
2)The torque output of the engine will be reduced.
Conditions for Clearing the Fault Code
1)To validate the repair, perform a key cycle, and then use INSITE? electronic service tool to perform the 2)Diesel Exhaust Fluid Doser System Heater Test found under ECM Diagnostic Tests.
3)To validate the repair, perform the “Aftertreatment Diesel Exhaust Fluid Doser Pump Override Test” found under “ECM Diagnostic Tests” in the INSITE? electronic service tool
4)This fault code can not be cleared with INSITE? electronic service tool.
5)The ECM will turn off the amber CHECK ENGINE lamp immediately after the diagnostic runs and passes.
6)The inactive fault code will be cleared from the memory after 9600 hours of engine operation without a reoccurrence.
Possible causes:
1)Malfunctioning aftertreatment diesel exhaust fluid tank heater control valve
2)An open circuit in the harness
3)A short circuit to battery in the harness.
Related
Categories Cumminz, ISB6.7 CM2350 (2013-17)Tags 1, 17, 2013, 31, 5278, 6802, Aftertreatment, CM2350, Code, Condition, Conditions, Cummins, Detected, Diesel, Dosing, ECM, Exhaust, Exists, Fault, Fluid, FMI, Frozen, frozen., has, indicate, is, ISB6.7, PID, SPN, System, the, which
Wiring Diagrams
Component Locators
- Volvo Penta EPC 6 Offline VMware [12.2021] VMware
Trucks software$64.00
Rated 0 out of 5
- VOLVO PTT TECH TOOL 2.8.220 2023 Last version 1pc
Trucks software$200.00
Rated 0 out of 5
- Thermo King EPC 2012
Thermo King$45.00
Rated 0 out of 5
- Volvo Premium Tech Tool PTT 2.8.130 Diagnostic Software 04.2022 ACPI ( 1 PC )
Trucks software$143.00
Rated 0 out of 5
- Bobcat Service Library [03.2019] Service, Operator, Maintenance, Bulletines, etc full update
Bobcat$110.00
Rated 0 out of 5
- CAT ET 2022A Advanced diagnostic software for Caterpillar equipment
CAT$95.00
Rated 0 out of 5
- AGCO EDT 2023.10 Electronic Diagnostic Tool 1.125
AGCO$120.00
Rated 0 out of 5
- Navistar Engine Diagnostics (NEDS) Software 2023
Navistar$96.00
Rated 0 out of 5
- Caterpillar CAT ET 2021B Electronic Technician + Factory Password (1PC)
CAT$75.00
Rated 0 out of 5
- Wabco PIN Code Calculator Diagnostic Software PIN 1 PIN 2
Trucks software$10.00
Rated 0 out of 5
- Nexiq eTechnician 2.0.7447 2020
NEXIQ$55.00
Rated 0 out of 5
- download Hitachi Construction Machinery MPDr Ver 3.7.0.0 [10.2020] Diagnostic Software
Hitachi$76.00
Rated 0 out of 5
JPRO$94.00
Rated 0 out of 5
- Cumming Caltem 5.9.1 2022 ( 1 PC )
cummisznn$78.00
Rated 0 out of 5
- MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog
MAN$80.00
Rated 0 out of 5
- Detroit BackDoor Password Generator V1 V2
Detroit$30.00
Rated 0 out of 5
- DOWNLOAD Volvo VODIA 5.2.50 works with VOCOM + video
Trucks software$98.00
Rated 0 out of 5
Scania$30.00
Rated 0 out of 5
Hitachi$125.00
Rated 0 out of 5
- Meritor Wabco Tool Box 12.9.1
Trucks software$35.00
Rated 0 out of 5
Related products
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3255 PID: SPN:3246 FMI:0 Aftertreatment Diesel Particulate Filter Outlet Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3316 PID: SPN:3242 FMI:4 Aftertreatment 1 Diesel Particulate Filter Intake Temperature Sensor Circuit – Voltage Below Normal or Shorted to Low Source
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3253 PID: SPN:3242 FMI:0 Aftertreatment Diesel Particulate Filter Intake Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3321 PID: SPN:3246 FMI:4 Aftertreatment 1 Diesel Particulate Filter Outlet Temperature Sensor Circuit – Voltage Below Normal or Shorted to Low Source
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3239 PID: SPN:4342 FMI:3 Aftertreatment 1 Diesel Exhaust Fluid Line Heater 2 Circuit – Voltage Above Normal or Shorted to High Source
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3253 PID: SPN:3242 FMI:16 Aftertreatment Diesel Particulate Filter Intake Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:324 PID:SID 3 SPN:653 FMI:5 Injector Solenoid Driver Cylinder 3 Circuit – Current Below Normal or Open Circuit
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3314 PID: SPN:4765 FMI:3 Aftertreatment 1 Diesel Oxidation Catalyst Intake Temperature Sensor Circuit – Voltage Above Normal or Shorted to High Source
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3258 PID: SPN:4340 FMI:5 Aftertreatment 1 Diesel Exhaust Fluid Line Heater 1 Circuit – Current Below Normal or Open Circuit
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3231 PID: SPN:4360 FMI:16 Aftertreatment SCR Intake Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3251 PID:S326 SPN:4765 FMI:0 Aftertreatment Diesel Oxidation Catalyst Intake Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3256 PID: SPN:3246 FMI:0 Aftertreatment Diesel Particulate Filter Outlet Temperature – Data Valid But Above Normal Operating Range – Least Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3254 PID: SPN:3242 FMI:15 Aftertreatment Diesel Particulate Filter Intake Temperature – Data Valid But Above Normal Operating Range – Least Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3255 PID: SPN:3246 FMI:16 Aftertreatment Diesel Particulate Filter Outlet Temperature – Data Valid But Above Normal Operating Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
- PACCAR PX-9 CM2350 (2013-17) Fault Code:3245 PID: SPN:3936 FMI:7 Aftertreatment 1 Diesel Particulate Filter System – Mechanical System Not Responding or Out of Adjustment
DTC TRUCKS
Rated 0 out of 5
- SERVICE MANUAL EATON CEEMAT TRSM0020
EATON$24.00
Rated 0 out of 5
- SERVICE MANUAL Carrie 40 and 50 X
CARRIE$20.00
Rated 0 out of 5
- SERVICE MANUAL BOBCAT 323 sms
BOBCAT$60.00
Rated 0 out of 5
- SERVICE MANUAL TROUBLESHOOTING TC10 5TH GENERATION ALLISON
Allison$19.00
Rated 0 out of 5
CARRIE$20.00
Rated 0 out of 5
- SERVICE MANUAL WTEC 3 Allison Transmission
Allison$18.00
Rated 0 out of 5
- SERVICE MANUAL EPA04 Series 60 DDEC V Actuator Adjustment
DETROIT$18.00
Rated 0 out of 5
- SERVICE MANUAL DETROIT DIESEL DDEC II to III-IV Conversion
DETROIT$18.00
Rated 0 out of 5
- SERVICE MANUAL BOBCAT 974-975 sms
BOBCAT$35.00
Rated 0 out of 5
- SERVICE MANUAL Carrie Metrobird TDS 115
CARRIE$25.00
Rated 0 out of 5